VW Transporter T5 ESSENTIALS (from 09.2009-2014) – Fuse box diagram
Year of manufacture: 2009, 2010, 2011, 2012, 2013, 2014.
Cigarette lighter fuse (power outlet) in the Volkswagen Transporter T5 ESSENTIALS Is the SF11 fuse in the fuse box.
Location of the fuse box
| Fuse box | Location |
| 1 – Fuse Holder D – SD | In the right engine compartment |
| 2 – Fuse holder B – SB | In the center dashboard panel |
| 3 – Fuse holder F – SF | Under the left seat |
| 4 – Fuse holder C – SC | in the center panel of the instrument panel |
| 5 – Fuse holder A – SA | In the left engine compartment |
Fuse holder F (left in the seat box)
| No. | Amp [A] | Description |
| SF1 | 15 | |
| SF2 | 3 | |
| SF3 | 15 | |
| SF4 | 15 | |
| SF5 | 5 | |
| SF6 | 25 | |
| SF7 | 30 |
12 V socket. |
| SF8 | 25 |
Heater controller; Remote control receiver for parking heater. |
| SF9 | 25 |
Fresh air fan isolation relay; Rear blower control motor. |
| SF10 | 3 |
Auxiliary heater relay |
| 15 | ||
| SF11 | 15 | Lighter |
| SF12 | 15 | |
| SF13 | – |
Empty |
| SF14 | – |
Emptiness |
| SF15 | – |
Emptiness |
| SF16 | – |
Empty |
| SF17 | – |
Empty |
| SF18 | – |
Empty |
| SF19 | – |
Empty |
| SF20 | – |
Empty |
| SF21 | – |
Emptiness |
| SF22 | 15 | 12 V socket 2 |
| SF23 | 15 | 12 V socket 3 |
| SF24 | 10 |
Models with additional heater only coolant |
| 15 | ||
| SF25 | 10 |
Trailer detector control unit -J345-30 |
| SF26 | 20 |
Trailer detector control unit -J345-30 |
| SF27 | 20 |
Trailer detector control unit -J345-30 |
| SF28 | 7,5 |
System control unit reversing camera -J772-30a |
| SF29 | – | Empty |
| SF30 | 5 |
Voice amplification control unit -J656-30 |
| SF31 | – | Empty |
| SF32 | – | Empty |
| SF33 | 15 |
Driver’s lumbar support adjustment switch 30 |
| SF34 | 40 |
Right Sliding Door Control Unit -J731- |
| SF35 | 80 |
Battery isolation relay -J7-30 |
| SF36 | 40 |
17-pin connector |
Fuse holder D in the electronics box in the engine compartment
| No. | Amp [A] | Description |
| 1 | 5 |
Radiator Fan Control Unit -J293-87 |
| 2 | 5 |
Additional cooling pump relay -J496-30 |
| 3 | 5 |
Heating element for crankcase opening -N79-15 |
| 4 | – | Empty |
| 5 | 15 |
Mechatronic unit for double-clutch transmission -30 J743-; Shift lever locking solenoid valve -N110-; Gearshift lever. |
| 6 | 30 |
ABS control unit -J104-30 |
| 7 | – | Empty |
| 8 | – | Empty |
| 9 | 5 |
Engine control unit -J623-30 |
| 10 | 5 |
Secondary air pump relay -J299- |
| 15 |
Load pressure control solenoid valve -N75-; Activated carbon filter system solenoid valve -valve 1 -N80-; Exhaust gas recirculation cooler bypass valve -N345-; Charge pressure control valve 2 -N274-. |
|
| 11 | 30 |
High beam relay -J12- |
| 12 | 10 |
Fuel metering valve -N290-15-; Fuel pressure regulating valve -N276- or 87. |
| 13 | 10 |
Left discharge light driver -J343-15 |
| 14 | 5 |
Fuel pump relay -J17-15-; Auxiliary fuel pump relay -J832-; Clutch pedal switch -F36-. |
| 15 | 10 |
Reversing Light Switch -F4-15 |
| 16 | 5 |
Air mass meter -G70-15; Brake light switch -F-17-. |
| 17 | 5 |
TCS and ESP Button -E256-15-; ABS control unit -J104-. |
| 18 | 5 |
Power steering control unit -J500- |
| 19 | 5 |
Clutch pedal switch -F36-15-; Air mass meter -G70-1. |
| 20 | 5 |
Engine control unit -J623-15 |
| 21 | 5 |
Exhaust gas recirculation valve -N18-87 |
| 22 | 10 |
Injector, cylinder 1 -N30-87a- Injector, cylinder 2 -N31-; Injector, cylinder 3 -N32-; Injector, cylinder 4 -N33-. |
| 23 | 10 |
Right Flush Light Control Unit -J344-15 |
| 24 | 5 |
Mechatronic unit for double-clutch transmission -15 J743-; Gear shift lever -E313-. |
| 25 | 30 |
Engine control unit -J623-87-; Ignition transformer -N152-. |
| 26 | 5 |
Left side daytime running lamp -L174-87 |
| 27 | 10 |
Continuous refrigerant circulation pump -V51-87 |
| 28 | 15 |
Tweeter horn -H2-4) 30 |
| 29 | 5 |
Daytime running lamp on the right -L175-87 |
| 30 | 20 |
Fuel system pressure pump -G6-30-; Fuel pump relay -J17-; Auxiliary fuel pump relay -J832-. |
| 31 | 15 |
Lambda probe heater -Z19- Lambda probe heater 1 after catalytic converter -Z29-2) |
| 32 | 30 |
Motor Controller -J623-5A-; Electric fuel pump 2 relay -J49-2. |
| 33 | 5 |
Additional cooling pump relay -J496-87 |
| 34 | 5 |
On-board power control unit -J519- (T73b / 59) 30 |
| 35 | – | Free 87 |
| 36 | 30 |
Additional cooling pump relay -J496-30 |
Warning:
1) only for engine codes CAAA, CAAB, CAAC, CCHA
2) only for engine code AXA
3) only Diesel models
4) only for models with cab equipment.
Fuse holder B and C – in the lower fuse box in the center of the instrument panel
Fuse holder B
| No. | Amp [A] | Description |
| 1 | 30 |
Terminal 15 supply voltage relay -J329-30 |
| 2 | 5 |
Steering angle transmitter -G85-30 |
| 3 | 10 |
On-board power control unit -J519-30 (T73b / 39) |
| 4 | 5 |
Connector W8 (15a), on rear wiring harness 15a-; Lane change assist control unit 2 -J770-; Lane change assist control unit -J769-. |
| 5 | 15 |
L1-56b- Left Filament Double Incandescent Lamp |
| 6 | 15 |
L1-56a-. Left headlight double filament bulb. |
| 7 | 15 |
On-board power control unit -J519- (T73a / 66) 1) |
| 8 | 15 |
Back Cover Controller -J605-30-20A-; Beeper -H12-30-; On-board power control unit -J519- (T73/16)-. Left sliding door control unit -J558-; Rear cover control unit -J605-; Right sliding door control unit -J731-. |
| 9 | 30 |
On-board power control unit -J519-30 |
| 10 | 10 |
Intermittent wiper switch -E22-15-; Rear wiper switch -E34-; Intermittent wiper control -E38-. |
| 11 | 5 |
License plate illumination -X-58 |
| 12 | 5 |
Light switch -E1-30 30 30 A |
| 13 | 7,5 |
Airbag control unit -J234-15 |
| 14 | 25 |
Electronic Steering Column Controller -30 J527- |
| 15 | 7,5 |
Fresh air blower switch -E9-75 |
| 16 | 5 |
On-board power control unit -J519-15 (T73a/44) |
| 17 | 5 |
Rear fog warning light -K13-RFL-; Rear left fog lamp -L46-. |
| 18 | 5 |
Dashboard control unit -J285-30 |
| 19 | 5 |
Ignition/starter switch -D-86s |
| 20 | 5 |
Diagnostic link -U31-30 |
| 21 | 10 |
Starter Relay -J53-50-; Engine control unit -J623-. |
| 22 | 7,5 |
In-dash control unit -J285-15-; Diagnostic connector -U31-(T16/1). |
| 23 | 30 |
Ignition/starter switch -D- 50 5 A-; On-board power control unit -J519-(T73b/50)-; |
| 24 | 5 |
Steering angle transmitter -G85-15 |
| 25 | 7,5 |
Fresh air blower switch -E9-30 |
| 26 | 30 |
Light Switch -E1-75x |
| 27 | 15 |
L2- 56b- B456 double filament right headlight bulb; Connection (56b), in the main wiring harness – wiring harness. |
| 28 | 15 |
Double filament right headlight bulb -L2- 56a- B142 Positive connection 2 (56a), inside – wiring harness; Control unit on instrument panel inserted -J285- (T32/14)-; |
| 29 | 10 |
Dual-signal inverter relay -J741-30a |
| 30 | 10 |
Left washer heating element -Z20-75-; Right washer heating element -Z21-; Rear wiper motor -V12-; Right rear door wiper motor -V93-; Left rear door wiper motor -V92-. |
| 31 | 30 |
On-board power control unit -J519-30 (T73 /73) |
| 32 | 30 |
On-board power control unit -J519-30 (T73a/68) |
| 33 | 30 |
Radio -R-30-; Control unit with display for radio and navigation system -J503-. |
| 34 | 25 |
Relief relay contact X -J59-15-; Fuse 14 in fuse holder D -SD14-; Fuse 20 in fuse holder D -SD20-. |
| 35 | 5 |
B340 Connection 1 (58d), on main harness 58d – B341; Connection 2 (58d), on the main wiring harness B342; Connection 3 (58d), in the main wiring harness. |
| 36 | 25 |
On-board power control unit -J519-30 (T73b/13) |
Warning:
1) only for models with roof console
Fuse holder C
| No. | Amp [A] | Description |
| 1 | 15 | Trailer detector control unit -J345-15a-;
10-pin connector-T10bh/1-75a. |
| 2 | 5 | Internal monitor transmits and receives module 2 -30-G305-;
Anti-theft and tilting system control unit -J529-. |
| 3 | 101 | Emergency light switch -E10- 30 15A-;
Illuminated warning lamp -K100-. |
| 4 | 10 | Differential lock control unit -J187-15a-;
Rear differential lock switch -E121-; Four-wheel drive control unit -J492-. |
| 5 | 5 | SC5-10A-6-pin connector -T6bn / 5-75x |
| 6 | 5 | Oil level and temperature transmitter -G266-15 |
| 7 | 30 | Rotating Light Switch -E162- 30 10 A |
| 8 | 5 | Parking aid control unit -J446-30 |
| 9 | 5 | Electronic steering column controller -30 J527-;
Adaptive speed controller -J428-. |
| 10 | 10 | Left headlight range control motor -V48- 15 5 A-;
Right headlight range control motor -V49-; Instrument light switches and controller -E20. |
| 11 | 15 | Left Sliding Door Control Unit -J558-58 |
| 12 | 5 | Daytime running lamp left -L174-30 30 |
| 13 | 5 | Driveline CAN bus isolation relay -J788-15 |
| 14 | 5 | Daytime Running Lamp right -L175-30A |
| 15 | 5 | Electronic control unit for cell phones -J412- |
| 16 | 7,5 | TV navigation system tuner -J415-30-;
Interface for external multimedia device -R215-. |
| 17 | 7,5 | On-board power control unit -J519-.
(T73 / 66) 30 1) -1) 30G 2) Interior lighting and compartment lighting 2) |
| 18 | 5 | Air conditioning system control unit -J301-30-;
Rear fresh air fan switch -E179-; Rear panel control and display unit -Climatronic -E265-; Rear blower control transmitter -G463-. |
| 19 | 5 | Auto-dimming interior mirror -Y7- 86s |
| 20 | 10 | On-board power control unit -J519-30 (T73a / 64) |
| 21 | 5 | Rain Sensor -G213-RPL |
| 22 | 5 | A/C system pressure switch -15-F129-;
Air quality sensor -G238-. |
| 23 | 10 | Residual heat relay -J708-30a-;
Remote control receiver for auxiliary refrigerant -heater -R149-; Operating and display unit for auxiliary heater -E407-; Camping equipment operating and display unit -E153-. |
| 24 | 7,5 | Left center reading light -W39-30G-
Right center reading light -W40-; Left rear reading light -W11-; Right rear reading light -W12-; Left interior light -W16-; Interior light right -W17-; Left rear interior lighting -W47-; Interior light right rear -W48-. |
| 25 | 25 | Seat heating controller with regulator -J396- |
| 26 | 10 | Tachograph -G24-30 |
| 27 | 30 | D51 Positive connection 1 (15), in engine compartment wiring harness 15 -;
Fuse 13 in fuse holder D -SD13-; Fuse 23 in fuse holder D -SD23-. |
| 28 | 5 |
Mirror adjustment switch -E43-15-; Outer mirror heating knob -E231-. |
| 29 | 25 |
Heater control unit -J162-30 |
| 30 | 5 |
Operating and display unit for camping equipment 75 -E153-; Auxiliary cooling heater relay -J493-. |
| 31 | 25 |
Sliding roof control unit -30 5 AJ245- |
| 32 | 20 |
Headlight Washer Relay System -J39-15 |
| 33 | 5 |
Tachograph -G24-15 |
| 34 | 5 | Free |
| 35 | 20 |
On-board power control unit -J519-30 (T73b / 11) |
| 36 | 5 |
10-pin connector -T10bh / 9-30 |
Warning:
1) only for models without roof console
2) only for models with roof console.
Fuse holder A – in the engine compartment
| No. | Amp[A] | Description |
| 1 | 175 |
Alternator -C-30225 A- |
| 2 | 125 |
Relief relay contact X -J59-30- B298; Positive connection 2 (30), on the main wiring harness -B301; Positive connection 5 (30), on main wiring harness -B302; Positive connection 6 (30), on main wiring harness B303; Positive connection 7 (30), on main wiring harness B304; Positive connection 8 (30), on main wiring harness B305; Positive connection 9 (30), on main wiring harness Fuse 9 in fuse holder B -SB9-; Fuse 14 in fuse holder B – SB14-. |
| 3 | 50 |
Battery isolation relay -J7-30100A-; Second battery charging circuit -J713- B310; Positive connection 14 (30), on the main wiring harness B311; Positive connection 15 (30), on the main wiring harness. |
| 4 | 70 |
D50 Positive connection (30) in engine compartment wiring 30 |
| 5 | 50 |
ABS control panel fuse 1 -S123- 30-. Fuse 6 in fuse holder D -SD6-. |
| 6 | 60 |
Automatic light period control unit -30 50 A-J179-; Secondary air pump relay -J299-. |
| 7 | 100 |
Radiator Fan Control Unit -J293-30 |
| 8 | 40 |
Adiator fan controller -J293-30 8- Fuse -40 A – B169 Positive connection 1 (30), w 30 50 A internal wiring harness 100 A- B170 Positive connection 2 (30), in internal wiring harness; Fuse 9 in fuse holder F -SF9-; Fuse 14 in fuse holder F -SF14-; Fuse 22 in fuse holder F -SF22-; Fuse 23 in fuse holder F -SF23-; Fuse 24 in fuse holder F -SF24-. |
| 9 | 100 |
B272 Positive connection (30), on main 30 – wiring harness; B299 Positive connection 3 (30), on main 30 – wiring harness. |
