Fuse diagram and relay box – Ford Windstar
Applies to new vehicles in years:
1994, 1995, 1996, 1997, 1998.
Passenger compartment fuse box
The fuse panel is located under the instrument panel.
- To remove the fuse panel cover, pull down on the fuse panel cover handle.
- On the fuse panel, find the number of the fuse you want to check.
- Use the fuse pull tool to remove the fuse.
- Check the fuse to see if it is blown. Look through the clear side of the fuse to see if the metal wire inside is separated. If it is, the fuse is blown and should be replaced with a fuse of the correct amperage.
- Put the fuse panel cover back on.
Even after replacing the fuse, it will still blow if the cause of the overload is not found. If the fuse still blows, check the wiring.
| Number | Amps [A] | Description |
| 1 | 10 | Power supply mirror/theft warning light/power supply diagnostic link |
| 2 | 10 | Rear LH, stop, parking lights |
| 3 | 5 | Instrument cluster/mobile radio/lighter lighter lighter/heated backlight switch/heat control/lock/electric windows/rear wiper switch/rear heater switch/fog light switch |
| 4 | 10 | Side marker lamps |
| 5 | 20 | Headlight Washer |
| 6 | 15 | Left Side Reversing Window/Right Side Reversing Window |
| 7 | 15 | High Mounted Brake Light/Right Stop Light/Left Stop Light/EWG/Lock Brake/Speed Gear Control |
| 8 | 10 | Rear lights straight, Stop, parking lights |
| 9 | – | Not used |
| 10 | 10 | High beam indicator (electronic instrument cluster only) |
| 11 | 15 | Park Lights |
| 12 | 10 | GEM module/anti-theft module/keyless access module/lamp failure module/receiver radio/remote radio/lamp failure module |
| 13 | 15 | Radio/CD Switch |
| 14 | 5 | Instrument cluster/electrochromic mirror |
| 15 | 15 | “GEM” |
| 16 | 15 | Horn / relay (coil) |
| 17 | 15 | Front fog lamps |
| 18 | 25 | Wiper/Washer Pump Relay |
| 19 | 10 | GEM/Electronic cluster |
| 20 | 25 | Ignition coil/ignition capacitor/IRCM |
| 21 | 10 | A/С clutch lock/shift lock/heated backlight relay (coil)/mixed door motor, electronic unit/airbag diagnostic module |
| 22 | 20 | Rear cigar lighter/feeder plug |
| 23 | 15 | Wipers and Flash to go |
| 24 | 20 | Rear wiper motor/rear washer pump |
| 25 | 10 | R direction indicators/indicators (cluster) |
| 26 | 10 | Aero left headlight |
| 27 | 15 | Daytime Running Lights |
| 28 | 15 | Front cigarette lighter |
| 29 | 15 | Battery saver relay (solenoid)/ interior lighting relays (solenoid)/ delay accessory relays (solenoid)/ display lights/ hood light/ glove box light/ second row reading light/ rail light/ pillar light/ garage light/ dome light/ courtesy light/ puddle light/ keyhole light/ keyless access module |
| 30 | 25 | Brake speed/pressure control switch |
| 31 | 10 | Load balancing compressor/Left and right spring solenoid valve |
| 32 | 10 | Aero headlight right |
| 33 | 15 | ABS/ABS relay module |
| 34 | 30 | Power window left/single button interference (coil) |
| 35 | 15 | Anti-theft module |
| 36 | 30 | A/C Mode Switch |
| 37 | 20 | Electric door lock motors |
| 38 | 15 | Heated mirrors |
| 39 | 30 | Rear heater fan motor |
| 40 | 30 | Power window on the right |
| 41 | – | Not used |
| 42 | – | Not used |
| 43 | – | Not used |
| 44 | – | Not used |
Fuse box in engine compartment
Located on the driver’s side in the engine compartment.
| Number | Amps [A] | Description |
| A | 50 | Towing a trailer |
| В | 60 | Engine Cooling Fans |
| С | 60 | Starter solenoid/fuse 30/fuse 36/fuse 2 |
| D | 60 | Fuse 6/Fuse 12/Fuse 8/Fuse 18/Fuse 14/Fuse 24/Fuse 20/Fuse 21/Fuse 27/Fuse 33 |
| E | 60 | Rear heating blower motor/fuse 39/air suspension |
| F | 60 | Electric seats |
| G | – | Not used |
| H | 40 | Engine Cooling Fans |
| J | 60 | Fuse 13/Fuse 25/Fuse 1/Fuse 34/Fuse 37/Fuse 40/Fuse 7/Fuse 19/Fuse 4 |
| K | 60 | Headlights/ fuse 10/ fuse II/ fuse 3/ fuse 9/ fuse 23/ fuse 29/ fuse 35/ fuse 41 |
| L | 60 | ABS pump control module/motor module |
| M | 60 | Heated backlight/fuse 16/fuse 28/fuse 22/fuse 38 |
| N | 20 | PCM/fuel pump |
| P | – | Not used |
| R | 15 | PCM Memory |
| S | 30 | Axis/cylinder identification sensor/EDIS module/PCM power supply/controlEGR/HEGO/lAC/injectors/MAFS/VMV |
| T | 15 | Internal regulator of the alternator |
| U | 10 | Airbag power |
| V | 10 | Overdrive cut-off light |
| W | 10 | PCM fan monitor |
| LED | ||
| D1 | Hood switch | |
Relay
One relay box is located with the maximum fuses near the battery and the other with the fuse panel under the dashboard.
